| |
Contact
us
|
Petrarch Material Safety Data Sheet
|  Material Safety Data
Sheet
|
U.S.
Department of Labor |
| May be used to comply
with |
Occupational Safety
and Health Administration |
| OSHA's Hazard Communication
Standard, |
(Non-Mandatory Form) |
| 29 CFR 1910.1200.
Standard must be |
Form Approved |
| consulted for specific
requirements. |
OMB No. 1218-0072 |
| IDENTITY
(As Used on Label and List)
Petrarch / Fasset Composite Panels |
Section I
| Manufacturer's
Name
CEP Panels, Ltd. c/o CEP Panels, Inc. |
Emergency Telephone Number
630-355-4040 |
| Address
(Number, Street, City, State, and ZIP Code)
22 East Chicago Ave.
Suite 210
Naperville, IL 60540 |
Telephone Number for Information
630-355-4040 |
| |
Date Prepared
1/8/04 |
| |
Signature
of Preparer (optional)
|
Section II - Hazard Ingredients/Identity Information
| Hazardous
Components (Specific Chemical Identity; Common Name(s)) |
OSHA
PEL |
ACGIH
TLV |
Other
Limits
Recommended |
%(optional) |
| Polyester resin, Glass fiber, Slate powder & granules, Calcium carbonate
Small quantities (less than 3%) of some of the following:
Antimony Oxide, brominated fire retardant, titanium dioxide, iron oxide,
chromium oxide, carbon black |
Section III - Physical/Chemical Characteristics
| Boiling
Point |
N/A |
Specific
Gravity (H2O = 1)
|
2.2 |
| Vapor Pressure
(mm Hg.) |
N/A |
Melting
Point |
N/A |
| Vapor Density
(AIR = 1) |
N/A |
Evaporation
Rate
(Butyl Acetate = 1) |
N/A |
| Solubility in Water
Insoluble |
| Appearance and Odor
Colored Panels with no odor |
Section IV - Fire and Explosion Hazard Data
| Flash
Point (Method Used)
N/A |
Flammable
Limits
N/A |
LEL
N/A |
UEL
N/A |
| Extinguishing Media
Dry chemical, carbon dioxide, foam, water |
| Special
Fire Fighting Procedures
None |
| Unusual
Fire and Explosion Hazards
None |
Section V - Reactivity Data
| Stability |
Unstable |
|
Conditions to Avoid
N/A |
| |
Stable |
X |
|
| Incompatibility (Materials to Avoid)
None |
| Hazardous Decomposition or Byproducts
None |
| Hazardous
Polymerization |
May Occur |
|
Conditions to Avoid
N/A |
| |
Will Not
Occur |
X |
|
Section VI - Health Hazard Data
| Route(s)
of Entry: |
Inhalation?
Yes |
Skin?
No |
Ingestion?
No |
| Health Hazards (Acute and Chronic)
When cutting or drilling
some dust may be generated |
| Carcinogenicity: |
NTP?
No |
IARC
Monographs?
No |
OSHA Regulated?
No |
| Signs and Symptoms of Exposure
Respiratory irritation |
| Medical
Conditions Generally Aggravated by Exposure
Pre-existing respiratory problems |
| Emergency and First Aid Procedures
Remove to fresh air. Seek
medical advice if breathing difficulties continue. |
| OSHA 174, Sept. 1985 |
Section VII - Precautions for Safe Handling and Use
| Steps to Be Taken in Case Material is Released or Spilled
Treat as non hazardous
material |
| Waste Disposal Method
Dispose of as non hazardous
material |
| Precautions to Be taken in Handling and Storing
Store the panels on a flat
surface clear of the ground and under cover. |
| Other Precautions
Panels should be carried
on edge and never lifted flat unless supported. |
Section VIII - Control Measures
| Respiratory Protection (Specify Type)
Use NIOSH (National Institute for Occupational Safety and
Health) approved N95 Particulate Respirator for
nuisance dust. (Suggested Manufactures: 3M, Gerson, Air Tek, or
Equivalent) |
| Ventilation |
Local
Exhaust
N/A |
Special
N/A |
| |
Mechanical
(General)
N/A |
Other
N/A |
| Protective
Gloves
None |
Eye Protection
Wear eye protection when cutting or drilling |
| Other Protective Clothing or Equipment
None |
| Work/Hygienic Practices
N/A |
| |
* U.S.G.P.O.: 1986 - 491 - 529/45775 |
Back to Top
|
Printable Version
A Portable Document File is available for printing. Click on
the image above. |
|
PETRARCH (Picture
Gallery) STONEFLEX
(Picture
Gallery) CONTACT
US